The operation performance of a single and two (in series) laboratory UASB reactors (working volume of 2.7 l, recycle ratio varied from 1:1 to 1:18) treating diluted wine vinasse was investigated under psychrophilic conditions (4-10°C). For a single UASB reactor seeded with granular sludge, the average organic loading rates (OLR) applied were 4.7, 3.7 and 1.7 g COD/l/d (hydraulic retention times (HRTs) were around 1 d) at 9-11, 6-7 and 4-5°C, respectively. The average total COD removal for preacidified vinasse wastewater was around 60% for all the temperature regimes tested. For two UASB reactors in series, the average total COD removal for treatment of non-preacidified wastewater exceeded 70% (the average OLRs for a whole system were 2.2, 1.8 and 1.3 g COD/l/d under HRTs of 2 days at 10, 7 and 4°C, respectively). In situ determinations of kinetic sludge characteristics (Vm and Km) revealed the existence of substantial mass-transfer limitations for the soluble substrates inside the reactor sludge bed. Therefore an application of higher recycle rations is essential for enhancement of UASB pre-treatment under psychrophilic conditions. The produced anaerobic effluents were shown to be efficiently post-treated aerobically - final effluent COD concentrations were around 0.1 g/l.
Psychrophilic one- and two-step systems for pre-treatment of winery waste water
S. V. Kalyuzhnyi, M. A. Gladchenko, V. I. Skylar, Ye. S. Kizimenko, S. S. Shcherbakov; Psychrophilic one- and two-step systems for pre-treatment of winery waste water. Water Sci Technol 1 August 2001; 44 (4): 23–31. doi: https://doi.org/10.2166/wst.2001.0169
Download citation file:
Impact Factor 1.915
CiteScore 3.3 • Q2
First Decision in 30 days